GEORGIA DEPARTMENT OF PUBLIC HEALTH
Food Service Establishment Inspection Report
Establishment Name:  Zoner's Pizza Joint
Address:  103 W General Screven WAY STE D
City:  Hinesville Time In:  03 :  20 PM Time Out:  05 :  15 PM
Inspection Date:    10/15/2019   CFSM:   Nick Harper
Purpose of Inspection:    Routine    Followup    Initial   
     Issued Provisional Permit    Temporary     
Risk Type:   1   2   3 Permit#:  FSP-089-000286
Risk Factors are food preparation practices and employee behaviors most commonly reported to the Centers for Disease Control and Prevention as contributing factors in foodborne illness outbreaks. Public Health Interventions are control measures to prevent illness or injury. Good Retail Practices are preventive measures to control the introduction of pathogens, chemicals, and physical objects into foods.
Last Score

90
Grade

A
Date

03/20/19
Prior Score

85
Grade

B
Date

11/01/18
CURRENT SCORE CURRENT GRADE
 
72
  
C
SCORING AND GRADING:     A=90-100    B=80-89    C=70-79    U≤69

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
(Mark designated compliance staus (IN, OUT, NA, or NO) for each numbered item. For items marked OUT, mark COS or R for each item as applicable.)

IN=in compliance    OUT=not in compliance    NO=not observed    NA=not applicable    COS=corrected on-site during inspection      R=repeat violation of the same code provision=2 points
Compliance Status COS R
1 IN OUT NA NO Supervision 4 points
  circle circle     1-2A. PIC present, demonstrates knowledge, performs duties circle circle
  circle circle circle   1-2B. Certified Food Protection Manager circle circle
2 IN OUT NA NO Employee Health, Good Hygienic Practices, Preventing Contamination by Hands 9 points
  circle circle     2-1A. Proper use of restriction & exclusion circle circle
  circle circle   circle 2-1B. Hands clean and properly washed circle circle
  circle circle circle circle 2-1C. No bare hand contact with ready-to-eat foods or approved alternate method properly followed circle circle
  4 points
  circle circle     2-2A. Management knowledge, responsibilities, reporting circle circle
  circle circle   circle 2-2B. Proper eating, tasting, drinking, or tobacco use circle circle
  circle circle   circle 2-2C. No discharge from eyes, nose, and mouth circle circle
  circle circle     2-2D. Adequate handwashing facilities supplied & accessible circle circle
  circle circle     2-2E. Response procedures for vomiting & diarrheal events circle circle
3 IN OUT NA NO Approved Source 9 points
  circle circle     3-1A. Food obtained from approved source circle circle
  circle circle circle circle 3-1B. Food received at proper temperature circle circle
  circle circle     3-1C. Food in good condition, safe, and unadulterated circle circle
  circle circle circle circle 3-1D. Required records: shellstock tags, parasite destruction circle circle
4 IN OUT NA NO Protection From Contamination 9 points
  circle circle circle circle 4-1A. Food separated and protected circle circle
  circle circle     4-1B. Proper disposition of returned, previously served, reconditioned, and unsafe food circle circle
  4 points
  circle circle circle   4-2A. Food stored covered circle circle
  circle circle circle   4-2B. Food-contact surfaces: cleaned & sanitized circle circle
 
Compliance Status COS R
5 IN OUT NA NO Cooking and Reheating of TCS Foods, Consumer Advisory 9 points
  circle circle circle circle 5-1A. Proper cooking time and temperatures circle circle
  circle circle circle circle 5-1B. Proper reheating procedures for hot holding circle circle
    4 points
  circle circle circle   5-2. Consumer advisory provided for raw and undercooked foods circle circle
6 IN OUT NA NO Holding of TCS Foods, Date Marking of TCS Foods 9 points
  circle circle circle circle 6-1A. Proper cold holding temperatures circle circle
  circle circle circle circle 6-1B. Proper hot holding temperatures circle circle
  circle circle circle circle 6-1C. Proper cooling time and temperature circle circle
  circle circle circle circle 6-1D. Time as a public health control: procedures and records circle circle
    4 points
  circle circle circle circle 6-2. Proper date marking and disposition circle circle
7 IN OUT NA NO Highly Susceptible Populations 9 points
  circle circle circle   7-1. Pasteurized foods used: Prohibited foods not offered circle circle
8 IN OUT NA NO Chemicals 4 points
  circle circle circle   8-2A. Food additives: approved and properly used circle circle
  circle circle     8-2B. Toxic substances properly identified, stored, used circle circle
9 IN OUT NA NO Conformance with Approved Procedures 4 points
  circle circle circle   9-2. Compliance with variance, specialized process and HACCP plan circle circle
GOOD RETAIL PRACTICES
(Mark the numbered item OUT, if not in compliance. For items marked OUT, mark COS or R for each item as applicable. R = Repeat Violation of the same code provision = 1 point)
Good Retail Practices are preventive measures to control the introduction of pathogens, chemicals, and physical objects into foods.
Compliance Status COS R
10 OUT Safe Food and Water, Food Identification 3 points
  circle 10A. Pasteurized eggs used where required circle circle
  circle 10B. Water and ice from approved source circle circle
  circle 10C. Variance obtained for specialized processing methods circle circle
  circle 10D. Food properly labeled; original container circle circle
11 OUT Food Temperature Control 3 points
  circle 11A. Proper cooling methods used: adequate equipment for temperature control circle circle
  circle 11B. Plant food properly cooked for hot holding circle circle
  circle 11C. Approved thawing methods used circle circle
  circle 11D. Thermometers provided and accurate circle circle
12 OUT Prevention of Food Contamination 3 points
  circle 12A. Contamination prevented during food preparation, storage, display circle circle
  circle 12B. Personal cleanliness circle circle
  circle 12C. Wiping cloths: properly used and stored circle circle
  circle 12D. Washing fruits and vegetables circle circle
13 OUT Postings and Compliance with Clean Air Act 1 point
  circle 13A. Posted: Permit/Inspection/Choking Poster/Handwashing circle circle
  circle 13B. Compliance with Georgia Smoke Free Air Act circle circle
 
Compliance Status COS R
14 OUT Proper Use of Utensils 1 point
  circle 14A. In-use utensils: properly stored circle circle
  circle 14B. Utensils, equipment and linens: properly stored, dried, handled circle circle
  circle 14C. Single-use/single-service articles: properly stored, used circle circle
  circle 14D. Gloves used properly circle circle
15 OUT Utensils, Equipment and Vending 1 point
  circle 15A. Food and nonfood-contact surfaces cleanable, properly designed, constructed, and used circle circle
  circle 15B. Warewashing facilities: installed, maintained, used; test strips circle circle
  circle 15C. Nonfood-contact surfaces clean circle circle
16 OUT Water, Plumbing and Waste 2 points
  circle 16A. Hot and cold water available; adequate pressure circle circle
  circle 16B. Plumbing installed; proper backflow devices circle circle
  circle 16C. Sewage and waste water properly disposed circle circle
17 OUT Physical Facilities 1 point
  circle 17A. Toilet facilities: properly constructed, supplied, cleaned circle circle
  circle 17B. Garbage/refuse properly disposed; facilities maintained circle circle
  circle 17C. Physical facilities installed, maintained, and clean circle circle
  circle 17D. Adequate ventilation and lighting; designated areas used circle circle
18 OUT Pest and Animal Control 3 points
  circle 18. Insects, rodents, and animals not present circle circle
Person in Charge (Signature)   (Print)   Nick Harper Date:   10/15/2019
Inspector (Signature)  
Follow-up: YES circle   NO circle
Follow-up Date:
Food Establishment Inspection Report Addendum
Violations cited in this report must be corrected within the time frames specified below, or as stated in the Georgia Department of Public Health Rules and Regulations Food Service Chapter 511-6-1, Rule .10 subsections (2)(h) and (i).
Establishment
Zoner's Pizza Joint		 Permit #
FSP-089-000286		 Date
10/15/2019
Address
103 W GENERAL SCREVEN WAY STE D 		City/State
HINESVILLE GA		 Zipcode
31313
TEMPERATURE OBSERVATIONS
Item/Location Temp Item/Location Temp Item/Location Temp
Cold Holding, Main Kitchen, Walk in Cooler, Chicken, wings 5:00pm 44.0 ° F Cold Holding, Main Kitchen, Reach In Cooler, Vegetables, cut romain lettuce 41.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, pepperoni, 4:30 43.0 ° F
Cold Holding, Main Kitchen, Prep Top Cooler, Vegetables, sliced mushrooms 4:30 55.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, meatballs, 4:30 56.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, sausage, 4:30 45.0 ° F
Cold Holding, Main Kitchen, Prep Top Cooler, Chicken, spicy 4:30 42.0 ° F Cold Holding, Main Kitchen, Walk in Cooler, Ambient, 44.0 ° F Cold Holding, Main Kitchen, Walk in Cooler, Cheese, 44.0 ° F
Cold Holding, Main Kitchen, Walk in Cooler, pepperoni, 44.0 ° F Cold Holding, Main Kitchen, Walk in Cooler, Dairy, butter 44.0 ° F Cold Holding, Main Kitchen, Walk in Cooler, Pork, ham 43.0 ° F
Cold Holding, Main Kitchen, Walk in Cooler, Chicken, wings 44.0 ° F Cold Holding, Main Kitchen, Counter Top/Table, tomato sauce, 48.0 ° F Cold Holding, Main Kitchen, Counter Top/Table, Cheese, ricotta 60.0 ° F
Cold Holding, Main Kitchen, Prep Top Cooler, Vegetables, Baby Spinach 41.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, Tomatoes, diced 41.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, Vegetables, pickled jalepeno 47.0 ° F
Cold Holding, Main Kitchen, Prep Top Cooler, pepperoni, 47.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, Vegetables, sliced mushrooms 58.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, Pork, ham 51.0 ° F
Cold Holding, Main Kitchen, Prep Top Cooler, meatballs, 49.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, sausage, 44.0 ° F Cold Holding, Main Kitchen, Prep Top Cooler, Chicken, spicy 44.0 ° F
Cold Holding, Main Kitchen, Prep Top Cooler, Cheese, 41.0 ° F        
Item
Number		 OBSERVATIONS AND CORRECTIVE ACTIONS
2-1B Violation of Code: [511-6-1.03(5)(b)] Observed employee wash hands in 3 compartment sink by dipping hands in detergent solution in wash compartment and then turn off faucet without using a paper towel. Observed second employee wash hands in 3 compartment sink.  New Violation.
2-2B Violation of Code: [511-6-1.03(5)(k)1&2] Observed employee drink sprite from a can over a prep table. In food preparation areas employees must use a single service beverage cup with a secure lid and straw that is handled to prevent contamination of the employee’s hands, the container, exposed food, clean equipment, utensils and linens, unwrapped single-service and single-use articles  New Violation.
4-2B Violation of Code: [511-6-1.05(7)(a)1] Observed significant build-up of food residue on pizza screens. Manager stated these can't be washed and are run through the oven to burn the food debris off of them. Observed build-up of food residue inside cheese container in prep-top.  New Violation.
6-1A Observed items stored on counter top, in prep top cooler, and in walk-in cooler above 41F.  New Violation.
17C Violation of Code: [511-6-1.07(5)(a),(b)] Observed vent fan not working in restroom. This is a violation on the previous inspection. Observed accumulation of food debris under prep tables, behind ovens, under dry storage shelves, behind chest freezer, and behind mixer. Observed sagging ceiling tiles in kitchen. These should be replace with smooth, non-porous tiles that are faced with a durable, smooth, cleanable material. Observed damage to walls throughout  Repeat Violation.
Remarks Facility does not have paper towels for hand sink.
Observed Sour Cream with best by date of 9/14/2019, Corrected on site by discarding.
*************************************************************** 10/16/2019 -- Informal Follow-up -- Time in: 3:05PM ***************************************************************
Walk-in was being serviced at time of visit. Technician stated that the evaporator coils were dirty and that the charge was low.
Discussed handwashing and provided handwashing poster.
Discussed and provided poster for cleaning and sanitizing clean in place equipment.
Person in Charge (Signature)    Date: 10/15/2019
Inspector (Signature) Christopher Gowen Date: 10/15/2019